Abstract
Anaerobic ammonium oxidation (Anammox) was a recent discovery of new energy-efficient, microbiologically mediated nitrogen removal process, which was mainly used for the treatment of rich ammonium wastewater of low C/N ratio in a high operating temperature of 35–40 °C. But the growth rate of anammox bacteria was extremely low and it was easily inhibited by many factors, which becomes a bottleneck problem in the application of this efficient nitrogen removal process in the actual wastewater treatment at ambient temperature. So, influence of several key factors (i.e., COD, methanol, hydrazine, hydroxylamine, pH, nitrate, and phosphate) on the nitrogen removal performance of the anammox process was researched to optimize the operation of the anammox process in a bio-filter, and the total nitrogen removal rate (R TN) and the linear correlation coefficient between the total nitrogen removal rate (R TN) and influent total nitrogen load (L TN) of it were assessed with the real municipal wastewater at ambient temperature. The results demonstrated that (1) the influent of COD <100 mg/L had no visible inhibition on the anammox process in the bio-filter, and the recommendation of COD <80 mg/L was suitable for the operation; (2) short-term shock load of methanol would give significant inhibition on the anammox bacteria, which could be restored by adding a small amount of hydrazine and hydroxylamine, but the recovery process was extremely slow; (3) when the influent total nitrogen load increased suddenly, and the removal capacity of the bio-filter was not enough, the temporary mixed dosing of hydroxylamine and hydrazine could enhance the nitrogen removal performance; (4) the anammox activity was very sensitive to the influent pH, and the best range of pH values was 7.3–7.6; (5) the nitrate of 23.56–463.14 mg N/L had no obvious effect on the nitrogen removal performance; and (6) the phosphate itself had no significant inhibition on the anammox bacteria physiologically and ecologically, but it could form a great deal of deposits, which would lead to the bio-filter plugging.
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig1_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig2_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig3_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig4_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig5_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig6_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig7_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig8_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig9_HTML.gif)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig10_HTML.jpg)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs12665-015-4232-y/MediaObjects/12665_2015_4232_Fig11_HTML.gif)
Similar content being viewed by others
References
Administration National Environmental Protection (2006) Water and wastewater detection and analysis method [M]. China Environmental Science Press, Bei**g
Chen CJ, Huang XX, Lei CX et al (2013) Effect of organic matter strength on anammox for modified greenhouse turtle breeding wastewater treatment. Bioresour Technol 148(11):172–179
Du R, Peng YZ, Cao SB et al (2014) Advanced nitrogen removal with simultaneous anammox and denitrification in sequencing batch reactor. Bioresour Technol 162(6):316–322
Egli K, Fanger U, Alvarezz PJJ et al (2001) Enrichment and characterization of an anammox bacterium from a rotating biological contactor treating ammonium rich leachate. Arch Microbiol 175(3):198–207
Im J, Gil K (2013) Changes in the characteristics of organic compounds depending on the nitritation efficiency. Environ Earth Sci 70(3):1297–1305
Im J, Jung J, Bae H et al (2014) Correlation between nitrite accumulation and the concentration of AOB in a nitritation reactor. Environ Earth Sci 72(1):289–297
** RC, Ma C, Yu JJ (2013) Performance of an anammox UASB reactor at high load and low ambient temperature. Chem Eng J 232(10):17–25
Kartal B, Rattray J, Strous M et al (2007) Candidatus “Anammmoxoglobus propionicus” a new propionate oxidizing species of anaerobic ammonium oxidizing bacteria. Syst Appl Microbiol 30(1):39–49
Kawagoshi Y, Fujisaki K, Tomoshige Y et al (2012) Temperature effect on nitrogen removal performance and bacterial community in culture of marine anammox bacteria derived from sea-based waste disposal site. J Biosci Bioeng 113(4):515–520
Lackner S, Gilbert EM, Vlaeminck SE et al (2014) Full-scale partial nitritation/anammox experiences—an application survey. Water Res 55(15):292–303
Lotti T, Kleerebezem R, Luello C, van Loosdrecht MCM (2014) Physiological and kinetic characterization of a suspended cell anammox culture. Water Res 60(1):1–14
Lu HF, Zheng P, Ji QX et al (2012) The structure, density and settleability of anammox granular sludge in high-rate reactors. Bioresour Technol 123(11):312–317
Meng FG, Su GY, Hu YF et al (2014) Improving nitrogen removal in an anammox reactor using a permeable reactive biobarrier. Water Res 58(1):82–91
Schmid M, Walsh K, Webb R et al (2003) Candidatus “Scalindua brodae”, sp. nov., Candidatus “Scalindua wagneri”, sp. nov., two new species of anaerobic ammonium oxidizing bacteria. Syst Appl Microbiol 26(4):529–538
Schmidt I, Sliekers O, Schmid M et al (2003) New concepts of microbial treatment processes for the nitrogen removal in wastewater. FEMS Microbiol Rev 27(4):481–492
Strous M, Heijnen JJ, Kuenen JG et al (1998) The sequencing batch reactor as a powerful tool for the study of slowly growing anaerobic ammonium-oxidizing microorganisms. Appl Microbiol Biotechnol 50(5):589–596
Strous M, Fuerst JA, Kramer EHM et al (1999a) Missing lithotroph identified as new planctomycete. Nature 400(6743):446–449
Strous M, Kuenen JG, Jetten MSM (1999b) Key physiology of anaerobic ammonium oxidation. Appl Environ Microbiol 65(7):3248–3250
Tian ZY, Li D, Zhang J (2009) Relations of the substrate concentration to the COD and pH in the anammox process. Environ Sci 30(11):219–223
Trigo C, Campos JL, Garrido JM et al (2006) Start-up of the anammox process in a membrane bioreactor. J Biotechnol 126(4):475–487
Van de Graaf AA, Mulder A, de Bruijn P et al (1995) Anaerobic oxidation of ammonium is a biologically mediated process. Appl Environ Microbiol 61(4):1246–1251
Van de Graaf AA, de Bruijn P, Robertson LA et al (1996) Autotrophic growth of anaerobic ammonium-oxidizing micro-organisms in a fluidized bed reactor. Microbiology 142(8):2187–2196
Van de Graaf AA, de Bruijn P, Robertson LA et al (1997) Metabolic pathway of anaerobic ammonium oxidation on the basis of 15N studies in a fluidized bed reactor. Microbiology 143(7):2415–2421
Van Dongen U, Jetten MSM, Van Loosdrecht MCM (2001) The SHARON®-Anammox®-process for treatment of ammonium rich wastewater. Water Sci Technol 44(1):153–160
Van Loosdrecht MCM, Jetten MSM (1997) Method for treating ammonia-comprising wastewater. Patent: PCT/Nl97/00482
Wijesekara SSRMDHR, Mayakaduwa Sonia S, Siriwardana AR (2014) Fate and transport of pollutants through a municipal solid waste landfill leachate in Sri Lanka. Environ Earth Sci 72(5):1702–1719
Yang JC, Zhang L, Hira D et al (2011) High-rate nitrogen removal by the anammox process at ambient temperature. Bioresour Technol 102(2):672–676
Acknowledgments
This work was financed by Major Science and Technology Program for water pollution control and management (2013ZX07202-010).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Tian, Z., Zhang, J. & Song, Y. Several key factors influencing nitrogen removal performance of anammox process in a bio-filter at ambient temperature. Environ Earth Sci 73, 5019–5026 (2015). https://doi.org/10.1007/s12665-015-4232-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12665-015-4232-y