Abstract
Pretreatment of activated sludge is an important step in increasing the reaction speed during anaerobic digestion by accelerating the hydrolysis process. It is necessary not only to analyze the changes in the general properties of the sludge before and after pretreatment but also to further analyze and evaluate the sludge structure and extracellular polymeric substances (EPS). In this study, the changes in coking sludge extracts after pretreatments with alkali, autoclaving, and Fe+ autoclaving were analyzed and compared using EPS heat extraction method. Moreover, the methane production potential of the pretreated coking sludge was investigated via biochemical methane potential (BMP) test. The results showed that after alkali, autoclaving, and Fe+ autoclaving, the concentration of protein and polysaccharide in the bound sludge extract accounted for approximately 40% and 28%, 62% and 51%, and 66% and 83% of the total protein and polysaccharide extracted from the sludge, respectively. In the experiment without pretreatment, there is no phenomenon of gas production from coking sludge. According to the BMP test results, Fe+ autoclaving pretreatment showed the highest methane production of 257 mL/gVSS. This study revealed that the analysis of sludge extracts was necessary in assessing the effects of anaerobic digestion pretreatment and methanogenic potential. Moreover, coking sludge showed higher methanogenic potential after Fe+ autoclaving pretreatment.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data availability
The datasets used and/or analyzed during the current study are available from the corresponding author on reasonable request.
References
Appels L, Baeyens J, Degreve J, Dewil R (2008) Principles and potential of the anaerobic digestion of waste-activated sludge. Prog Energy Combust Sci 34:755–781. https://doi.org/10.1016/j.pecs.2008.06.002
Chen Y, Cheng JJ, Creamer KS (2008) Inhibition of anaerobic digestion process: a review. Bioresour Technol 99:4044–4064. https://doi.org/10.1016/j.biortech.2007.01.057
Comte S, Guibaud G, Baudu M (2007) Effect of extraction method on EPS from activated sludge: an HPSEC investigation. J Hazard Mater 140:129–137. https://doi.org/10.1016/j.jhazmat.2006.06.058
Cui D, Tan C, Deng H, Gu X, Pi S, Chen T, Zhou L, Li A (2020) Biosorption mechanism of aqueous Pb2+, Cd2+, and Ni2+ ions on extracellular polymeric substances (EPS). Archaea 2020(8891543):1–9. https://doi.org/10.1155/2020/8891543
Du H, Fusheng L (2017) Characteristics of dissolved organic matter formed in aerobic and anaerobic digestion of excess activated sludge. Chemosphere 168:1022–1031. https://doi.org/10.1016/j.chemosphere.2016.10.108
Fang W, Zhang P, Zhang G, ** S, Li D, Zhang M, Xu X (2014) Effect of alkaline addition on anaerobic sludge digestion with combined pretreatment of alkaline and high pressure homogenization. Bioresour Technol 168:167–172. https://doi.org/10.1016/j.biortech.2014.03.050
Gao M, Liu R, Li B, Wei W, Zhang Y (2020) Characteristics of extracellular polymeric substances and soluble microbial products of activated sludge in a pulse aerated reactor. Environ Technol 41:2500–2509. https://doi.org/10.1080/09593330.2019.1573849
Guibaud G, Comte S, Bordas F, Dupuy S, Baudu M (2005) Comparison of the complexation potential of extracellular polymeric substances (EPS), extracted from activated sludges and produced by pure bacteria strains, for cadmium, lead and nickel. Chemosphere 59:629–638. https://doi.org/10.1016/j.chemosphere.2004.10.028
Herzberg M, Kang S, Elimelech M (2009) Role of extracellular polymeric substances (EPS) in biofouling of reverse osmosis membranes. Environ Sci Technol 43:4393–4398. https://doi.org/10.1021/es900087j
Jafari M, D'Haese A, Zlopasa J, Cornelissen E, Vrouwenvelder J, Verbeken KVK, Verliefde A, Loosdrecht M, Picioreanu C (2020) A comparison between chemical cleaning efficiency in lab -scale and full-scale reverse osmosis membranes: role of extracellular polymeric substances (EPS). J Membr Sci 609:118189. https://doi.org/10.1016/j.memsci.2020.118189
Kor-Bicakci G, Eskicioglu C (2019) Recent developments on thermal municipal sludge pretreatment technologies for enhanced anaerobic digestion. Renew Sust Energ Rev 110:423–443. https://doi.org/10.1016/j.rser.2019.05.002
Kumar R, Linga P, Moudrakovski I, Ripmeester JA, Englezos P (2008) Structure and kinetics of gas hydrates from methane/ethane/propane mixtures relevant to the design of natural gas hydrate storage and transport facilities. AICHE J 54:2132–2144. https://doi.org/10.1002/aic.11527
Li L, Li Z, Song K, Gu Y, Gau X (2020a) Improving methane production from algal sludge based anaerobic digestion by co-pretreatment with ultrasound and zero-valent iron. J Clean Prod 255:120214. https://doi.org/10.1016/j.jclepro.2020.120214
Li Q, Song W, Sun M, Li J, Yu Z (2020b) Response of Bacillus vallismortis sp. EPS to exogenous sulfur stress/induction and its adsorption performance on Cu(II). Chemosphere 251(126343):126343. https://doi.org/10.1016/j.chemosphere.2020.126343
Li XY, Yang SF (2007) Influence of loosely bound extracellular polymeric substances (EPS) on the flocculation, sedimentation and dewaterability of activated sludge. Water Res 41:1022–1030. https://doi.org/10.1016/j.watres.2006.06.037
Liu J, Yang M, Zhang J, Zheng J, Xu H, Wang Y, Wei Y (2018) A comprehensive insight into the effects of microwave-H2O2 pretreatment on concentrated sewage sludge anaerobic digestion based on semi-continuous operation. Bioresour Technol 256:118–127. https://doi.org/10.1016/j.biortech.2018.01.126
Liu Y, Fang H (2003) Influences of extracellular polymeric substances (EPS) on flocculation, settling, and dewatering of activated sludge. Crit Rev Environ Sci Technol 33:237–273. https://doi.org/10.1080/10643380390814479
Liu YQ, Liu Y, Tay JH (2004) The effects of extracellular polymeric substances on the formation and stability of biogranules. Appl Microbiol Biotechnol 65:143–148. https://doi.org/10.1007/s00253-004-1657-8
Lizama A, Figueiras C, Pedreguera A, Espinoza J (2019) Enhancing the performance and stability of the anaerobic digestion of sewage sludge by zero valent iron nanoparticles dosage. Bioresour Technol 275:352–359. https://doi.org/10.1016/j.biortech.2018.12.086
Macherzynski B, Wlodarczyk-Makula M (2018) Biochemical neutralization of coke excess sewage sludge during anaerobic digestion process. Chem Biochem Eng Q 32:239–246. https://doi.org/10.15255/CABEQ.2016.1041
Montusiewicz A, Lebiocka M, Rozej A, Zacharska E, Pawlowski L (2010) Freezing/thawing effects on anaerobic digestion of mixed sewage sludge. Bioresour Technol 101:3466–3473. https://doi.org/10.1016/j.biortech.2009.12.125
Mottet A, Francois E, Latrille E, Steyer JP, Deleris S, Vedrenne F, Carrere H (2010) Estimating anaerobic biodegradability indicators for waste activated sludge. Chem Eng J 160:488–496. https://doi.org/10.1016/j.cej.2010.03.059
Neumann P, Pesante S, Venegas M, Vidal G (2016) Developments in pre-treatment methods to improve anaerobic digestion of sewage sludge. Rev Environ Sci Biotechnol 15:173–211. https://doi.org/10.1007/s11157-016-9396-8
Niu Y, Liu J, Ma S, Li Y, **e L, Wei Y, Meng X (2019) Enhancement for anaerobic digestion of waste activated sludge based on microwave pretreatment combined with zero valent iron. Environ Sci (in Chinese) 40:1431–1438. https://doi.org/10.13227/j.hjkx.201806079
Perea-Moreno M, Sameron-Manzano E, Perea-Moreno A (2019) Biomass as renewable energy: worldwide research trends. Sustainability-basel 11. https://doi.org/10.3390/su11030863
Sheng G, Yu H, Li X (2010) Extracellular polymeric substances (EPS) of microbial aggregates in biological wastewater treatment systems: a review. Biotechnol Adv 28:882–894. https://doi.org/10.1016/j.biotechadv.2010.08.001
Tan F, Tang K, Zhang P, Guo Y, Qu M, Li Y (2019) Utilization of a hydrogen source from renewable lignocellulosic biomass for hydrogenation of nitroarenes. Chemcatchem 11:4189–4195. https://doi.org/10.1002/cctc.201900087
Wang J, Li L (2016) Sustainable energy development scenario forecasting and energy saving policy analysis of China. Renew Sust Energ Rev 58:718–724. https://doi.org/10.1016/j.rser.2015.12.340
Wang Z, Liu Y, Tay J (2007) Biodegradability of extracellular polymeric substances produced by aerobic granules. Appl Microbiol Biotechnol 74:462–466. https://doi.org/10.1007/s00253-006-0686-x
Wei J, Hao X, van Loosdrecht MCM, Li J (2018) Feasibility analysis of anaerobic digestion of excess sludge enhanced by iron: a review. Renew Sust Energ Rev 89:16–26. https://doi.org/10.1016/j.rser.2018.02.042
Xue Y, Liu H, Chen S, Dichtl N, Dai X, Li N (2015) Effects of thermal hydrolysis on organic matter solubilization and anaerobic digestion of high solid sludge. Chem Eng J 264:174–180. https://doi.org/10.1016/j.cej.2014.11.005
Zhang D, Wang J, Lin Y, Si Y, Huang C, Yang J, Huang B, Li W (2017) Present situation and future prospect of renewable energy in China. Renew Sust Energ Rev 76:865–871. https://doi.org/10.1016/j.rser.2017.03.023
Zhang S, Chang J, Liu W, Pan Y, Cui K, Chen X, Liang P, Zhang X, Wu Q, Qiu Y, Huang X (2018) A novel bioaugmentation strategy to accelerate methanogenesis via adding Geobacter sulfurreducens PCA in anaerobic digestion system. Sci Total Environ 642:322–326. https://doi.org/10.1016/j.scitotenv.2018.06.043
Zhang Y, Xu Z, Tu Y, Wang J, Li J (2020) Study on properties of coal-sludge-slurry prepared by sludge from coal chemical industry. Powder Technol 366:552–559. https://doi.org/10.1016/j.powtec.2020.03.005
Zhen G, Lu X, Kato H, Zhao Y, Li Y (2017) Overview of pretreatment strategies for enhancing sewage sludge disintegration and subsequent anaerobic digestion: current advances, full-scale application and future perspectives. Renew Sust Energ Rev 69:559–577. https://doi.org/10.1016/j.rser.2016.11.187
Funding
This work was supported by the National Natural Science Foundation of the People’s Republic of China (No. U1901218), and the Program for Science and Technology of Guangdong Province, People’s Republic of China (No. 2015B020235005 and No. 2018A050506009). All sources of funding for the research were from School of Environment and Energy, South China University of Technology.
Author information
Authors and Affiliations
Contributions
ZY designed and led most of the experiments, and XK assisted most of the experiments. BC helped analyze the sludge EPS. GQ and JW participated in the experimental design and provided proofreading and revision of the article. FL and CW provided valuable suggestions and viewpoint for the article. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Competing interests
The authors declare that they have no competing interests.
Ethics approval and consent to participate
Not applicable.
Consent for publication
Not applicable.
Additional information
Responsible Editor: Ta Yeong Wu
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Yang, Z., Kang, X., Chen, B. et al. Effects of alkali, autoclaving, and Fe+ autoclaving pretreatment on anaerobic digestion performance of coking sludge from the perspective of sludge extracts and methane production. Environ Sci Pollut Res 28, 13151–13161 (2021). https://doi.org/10.1007/s11356-020-11380-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-020-11380-0