Abstract
Plasma technologies have drawn attention as a possible way for biomass/waste conversion into valuable intermediate products, which could partially satisfy the growing energy demands. Thus, this experimental research aimed to determine the ability to gasify wood pellets to synthesis gas in the thermal air plasma environment. The influence of the plasma torch power, plasma-forming gas flow rate, and the equivalence ratio on biomass gasification was analyzed. The synthesis gas generation varied between 59.95 and 62.51%, while the H2/CO ratio ranged from 0.68 to 0.8. The producer gas’s highest H2 and CO concentrations were 26.6 and 33.35%, respectively, giving the H2/CO ratio of 0.8. The lower heating value of the produced synthesis gas ranged from 7.62 to 8.82 MJ/Nm3. The carbon conversion efficiency and the energy conversion efficiency were equal to 85.3–97.2% and 29.23–30.57%, respectively. The specific energy requirements varied between 165.47 and 195.61 kJ/mol of synthesis gas. Moreover, the energy and mass balance evaluation showed that generated producer gas could produce 15–18 kWh and 111–114 kWh of electrical and thermal energy, respectively, when 20.73 kg/h of wood pellets is gasified. Also, 28 and 33% of the electricity required for the air plasma formation can be received using producer gas in an internal combustion engine and microturbine.
Graphical abstract
Similar content being viewed by others
Data availability
Enquiries about data availability should be directed to the authors.
References
Abdul Malek ABM, Hasanuzzaman M, Rahim NA (2020) Prospects, progress, challenges and policies for clean power generation from biomass resources. Clean Technol Environ Policy 22:1229–1253. https://doi.org/10.1007/s10098-020-01873-4
Ascher S, Watson I, You S (2022) Machine learning methods for modelling the gasification and pyrolysis of biomass and waste. Renew Sustain Energy Rev 155:111902. https://doi.org/10.1016/j.rser.2021.111902
Barontini F, Frigo S, Gabbrielli R, Sica P (2021) Co-gasification of woody biomass with organic and waste matrices in a down-draft gasifier: an experimental and modeling approach. Energy Convers Manag 245:114566. https://doi.org/10.1016/j.enconman.2021.114566
Bolívar Caballero JJ, Zaini IN, Yang W (2022) Reforming processes for syngas production: a mini-review on the current status, challenges, and prospects for biomass conversion to fuels. Appl Energy Combust Sci 10:100064. https://doi.org/10.1016/j.jaecs.2022.100064
Cao Y, Fu L, Mofrad A (2019) Combined-gasification of biomass and municipal solid waste in a fluidized bed gasifier. J Energy Inst 92:1683–1688. https://doi.org/10.1016/j.joei.2019.01.006
Chaves LI, da Silva MJ, de Souza SNM et al (2016) Small-scale power generation analysis: downdraft gasifier coupled to engine generator set. Renew Sustain Energy Rev 58:491–498. https://doi.org/10.1016/J.RSER.2015.12.033
Delikonstantis E, Sturm G, Stankiewicz AI et al (2019) Biomass gasification in microwave plasma: an experimental feasibility study with a side stream from a fermentation reactor. Chem Eng Process Process Intensif 141:107538. https://doi.org/10.1016/j.cep.2019.107538
Elgarahy AM, Hammad A, El-Sherif DM et al (2021) Thermochemical conversion strategies of biomass to biofuels, techno-economic and bibliometric analysis: a conceptual review. J Environ Chem Eng 9:106503. https://doi.org/10.1016/j.jece.2021.106503
European Commission (2022) Communication from the commission to the European parliament, the European council, the council, the European economic and social committee and the committee of the regions. REPowerEU Plan, Brussels pp 1–21
Faraji M, Saidi M (2022) Process simulation and optimization of groundnut shell biomass air gasification for hydrogen-enriched syngas production. Int J Hydrogen Energy 47:13579–13591. https://doi.org/10.1016/j.ijhydene.2022.02.105
Ghodake GS, Shinde SK, Kadam AA et al (2021) Review on biomass feedstocks, pyrolysis mechanism and physicochemical properties of biochar: state-of-the-art framework to speed up vision of circular bioeconomy. J Clean Prod 297:126645. https://doi.org/10.1016/j.jclepro.2021.126645
Gil A (2022) Challenges on waste-to-energy for the valorization of industrial wastes: electricity, heat and cold, bioliquids and biofuels. Environ Nanotechnol Monit Manag 17:100615. https://doi.org/10.1016/j.enmm.2021.100615
Gimžauskaitė D, Aikas M, Tamošiūnas A (2022) Recent progress in thermal plasma gasification of liquid and solid wastes. Recent advances in renewable energy technologies. Elseiver, pp 155–196
Hrabovsky M, Hlina M, Kopecky V et al (2018) Steam plasma methane reforming for hydrogen production. Plasma Chem Plasma Process 38:743–758. https://doi.org/10.1007/s11090-018-9891-5
Ighalo JO, Iwuchukwu FU, Eyankware OE et al (2022) Flash pyrolysis of biomass: a review of recent advances. Clean Technol Environ Policy 24:2349–2363. https://doi.org/10.1007/s10098-022-02339-5
Kumar A, Bhattacharya T, Mozammil Hasnain SM et al (2020) Applications of biomass-derived materials for energy production, conversion, and storage. Mater Sci Energy Technol 3:905–920. https://doi.org/10.1016/j.mset.2020.10.012
Kuo PC, Illathukandy B, Wu W, Chang JS (2020) Plasma gasification performances of various raw and torrefied biomass materials using different gasifying agents. Bioresour Technol 314:123740. https://doi.org/10.1016/j.biortech.2020.123740
Ma W, Chu C, Wang P et al (2020) Characterization of tar evolution during DC thermal plasma steam gasification from biomass and plastic mixtures: parametric optimization via response surface methodology. Energy Convers Manag 225:113407. https://doi.org/10.1016/j.enconman.2020.113407
Ma WC, Chu C, Wang P et al (2020b) Hydrogen-rich syngas production by DC thermal plasma steam gasification from biomass and plastic mixtures. Adv Sustain Syst 4:2000026. https://doi.org/10.1002/adsu.202000026
Mallick D, Mahanta P, Moholkar VS (2020) Co-gasification of biomass blends: performance evaluation in circulating fluidized bed gasifier. Energy 192:116682. https://doi.org/10.1016/j.energy.2019.116682
Messerle V, Ustimenko A, Lavrichshev O et al (2020) Gasification of biomass in a plasma gasifier. Detritus 12:62–72. https://doi.org/10.31025/2611-4135/2020.13989
Messerle VE, Mosse AL, Ustimenko AB (2018) Processing of biomedical waste in plasma gasifier. Waste Manag 79:791–799. https://doi.org/10.1016/j.wasman.2018.08.048
Mingaleeva G, Ermolaev D, Galkeeva A (2016) Physico-chemical foundations of produced syngas during gasification process of various hydrocarbon fuels. Clean Technol Environ Policy 18:297–304. https://doi.org/10.1007/s10098-015-0988-8
Mourão R, Marquesi AR, Gorbunov AV et al (2015) Thermochemical assessment of gasification process efficiency of biofuels industry waste with different plasma oxidants. IEEE Trans Plasma Sci 43:3760–3767. https://doi.org/10.1109/TPS.2015.2416129
Muvhiiwa R, Sempuga B, Hildebrandt D (2021) Using the G-H space to show heat and work efficiencies associated with nitrogen plasma gasification of wood. Chem Eng Sci 243:116793. https://doi.org/10.1016/j.ces.2021.116793
Muvhiiwa RF, Sempuga B, Hildebrandt D, van der Walt J (2018) Study of the effects of temperature on syngas composition from pyrolysis of wood pellets using a nitrogen plasma torch reactor. J Anal Appl Pyrol 130:249–255. https://doi.org/10.1016/j.jaap.2018.01.014
Nobre C, Longo A, Vilarinho C, Gonçalves M (2020) Gasification of pellets produced from blends of biomass wastes and refuse derived fuel chars. Renew Energy 154:1294–1303. https://doi.org/10.1016/j.renene.2020.03.077
Ong Z, Cheng Y, Maneerung T et al (2015) Co-gasification of woody biomass and sewage sludge in a fixed-bed downdraft gasifier. AIChE J 61:2508–2521. https://doi.org/10.1002/aic.14836
Pio DT, Tarelho LAC, Tavares AMA et al (2020) Co-gasification of refused derived fuel and biomass in a pilot-scale bubbling fluidized bed reactor. Energy Convers Manag 206:112476. https://doi.org/10.1016/j.enconman.2020.112476
Rahman Z, Rahman H, Rahman A (2015) Classification and generation of atmospheric pressure plasma and its principle applications. Int J Math Phys Sci Res 2:127–146
Raimi D, Campbell E, Newell R, et al (2022) Global energy outlook 2022: turning points and tension in the energy transition a global energy outlook 2022
Rutberg PG, Bratsev AN, Kuznetsov VA et al (2011) On efficiency of plasma gasification of wood residues. Biomass Bioenergy 35:495–504. https://doi.org/10.1016/j.biombioe.2010.09.010
Samal S (2017) Thermal plasma technology: the prospective future in material processing. J Clean Prod 142:3131–3150. https://doi.org/10.1016/j.jclepro.2016.10.154
Sanjaya E, Abbas A (2023) Plasma gasification as an alternative energy-from-waste (EFW) technology for the circular economy: an environmental review. Resour Conserv Recycl 189:106730. https://doi.org/10.1016/j.resconrec.2022.106730
Siwal SS, Zhang Q, Devi N et al (2021) Recovery processes of sustainable energy using different biomass and wastes. Renew Sustain Energy Rev 150:111483. https://doi.org/10.1016/j.rser.2021.111483
Striūgas N, Valinčius V, Pedišius N et al (2017) Investigation of sewage sludge treatment using air plasma assisted gasification. Waste Manag 64:149–160. https://doi.org/10.1016/j.wasman.2017.03.024
Surov AV, Popov SD, Popov VE et al (2017) Multi-gas AC plasma torches for gasification of organic substances. Fuel 203:1007–1014. https://doi.org/10.1016/j.fuel.2017.02.104
Tamošiūnas A, Gimžauskaitė D, Uscila R, Aikas M (2019) Thermal arc plasma gasification of waste glycerol to syngas. Appl Energy 251:113306. https://doi.org/10.1016/j.apenergy.2019.113306
Tavares R, Ramos A, Rouboa A (2019) A theoretical study on municipal solid waste plasma gasification. Waste Manag 90:37–45. https://doi.org/10.1016/j.wasman.2019.03.051
Tezer Ö, Karabağ N, Öngen A et al (2022) Biomass gasification for sustainable energy production: a review. Int J Hydrogen Energy 47:15419–15433. https://doi.org/10.1016/j.ijhydene.2022.02.158
Ubando AT, Felix CB, Chen WH (2020) Biorefineries in circular bioeconomy: a comprehensive review. Bioresour Technol 299:122585. https://doi.org/10.1016/j.biortech.2019.122585
Van Caneghem J, Van Acker K, De Greef J et al (2019) Waste-to-energy is compatible and complementary with recycling in the circular economy. Clean Technol Environ Policy 21:925–939. https://doi.org/10.1007/s10098-019-01686-0
Wang W, Snoeckx R, Zhang X et al (2018) Modeling plasma-based CO2 and CH4 conversion in mixtures with N2, O2, and H2O: the bigger plasma chemistry picture. J Phys Chem C 122:8704–8723. https://doi.org/10.1021/acs.jpcc.7b10619
Zheng J, Yang R, **e L et al (2010) Plasma-assisted approaches in inorganic nanostructure fabrication. Adv Mater 22:1451–1473. https://doi.org/10.1002/adma.200903147
Funding
The authors declare that no external funding was received for this work.
Author information
Authors and Affiliations
Contributions
MA and RU prepared the experimental bench. DG, AT, MA, RU, and VS conducted the experimental research and collected the data. MA, DG, and AT analyzed the data and wrote the manuscript. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Conflict of interest
The authors declare no conflict of interest for this experimental research article.
Ethical approval
This article does not contain studies involving living-being organisms, including human or animal subjects.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Aikas, M., Gimžauskaitė, D., Tamošiūnas, A. et al. Thermal arc air plasma application for biomass (wood pellets) gasification. Clean Techn Environ Policy 26, 31–43 (2024). https://doi.org/10.1007/s10098-023-02566-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10098-023-02566-4