Abstract
There are several configurations of fluidized beds commonly used in wastewater treatment units. Often their hydrodynamics is challenging to be evaluated experimentally, or too complex to be predicted accurately with empirical correlations only. In the present study, the computational fluid dynamics technique was applied to evaluate the hydrodynamic behavior of a liquid–solid fluidized bed in tapered bioreactors. The simulations were run with OpenFOAM, and they were based on a 3D, transient, Eulerian–Eulerian two-phase approach coupled with a turbulence model. Different tapered bioreactor angles were considered in the study, and the results showed a decrease in flow velocity along with the height of the device. Moreover, the distribution of the bioparticles within the fluidized bed was not found to be uniform, and it changed with the angle. It was also observed that bioparticle collisions caused large velocity fluctuations. Even though the bioreactor presented a square cross section, results also proved that the presence of the dead zone was negligible.
Similar content being viewed by others
Abbreviations
- C :
-
Coefficient (–)
- e :
-
Coefficient of restitution (–)
- f(α):
-
Particles population effect
- g :
-
Gravity acceleration (m/s²)
- k :
-
Turbulent kinetic energy (m²/s²)
- M :
-
Momentum transfer term (kg/(m² s²))
- p :
-
Pressure (Pa)
- P :
-
Turb. kinetic energy production (m²/s³)
- Re :
-
Reynolds number (–)
- Sr :
-
Strain rate (–)
- t :
-
Time (s)
- U :
-
Velocity (m/s)
- α :
-
Volume fraction (–)
- δ :
-
Biofilm thickness (µm)
- ϵ :
-
Turb. kinetic energy dissipation (m²/s³)
- γ :
-
Gran. temperature dissipation (m²/s³)
- λ :
-
Bulk viscosity (kg/(m s))
- μ :
-
Dynamic viscosity (kg/(m s))
- ϕ :
-
Tapered bioreactor angle (°)
- ρ :
-
Density (kg/m³)
- σ :
-
Turbulence model constant (–)
- Θ :
-
Granular temperature (m²/s²)
- D :
-
Drag
- L :
-
Lift
- r :
-
Relative
- l :
-
Liquid phase
- p :
-
Particulate phase
References
Bello MM, Abdul Raman AA, Purushothaman M (2017) Applications of fluidized bed reactor in wastewater treatment—a review of the major design and operational parameters. J Clean Prod 10:1492–1514. https://doi.org/10.1016/j.jclepro.2016.09.148
Cornelissen JT, Taghipour F, Escudié R, Ellis N, Grace JR (2007) CFD modelling of a liquid–solid fluidized bed. Chem Eng Sci 62(22):6334–6348. https://doi.org/10.1016/j.ces.2007.07.014
Cresson R (2006) Etude du démarrage de procédés intensifs de méthanisation: Impact des conditions hydrodynamiques et de la stratégie de montée en charge sur la formation et l’activité du biofilm. Ph.D. Thesis, Université de Montpellier, France
Di Felice R (1995) Hydrodynamics of liquid fluidization. Chem Eng Sci 50(8):1213–1245. https://doi.org/10.1016/0009-2509(95)98838-6
Fan LS (1989) Gas–liquid–solid fluidization engineering. Butterworth-Heinemann, Boston
García-Calderón D, Buffière P, Moletta R, Elmaleh S (1998) Influence of biomass accumulation on bed expansion characteristics of a down-flow anaerobic fluidized-bed reactor. Biotechnol Bioeng 57:136–144. https://doi.org/10.1002/(SICI)1097-0290(19980120)57:2%3c136:AID-BIT2%3e3.0.CO;2-O
Grady Jr CPL, Daigger GT, Love NG, Filipe CDM (2011) Biological wastewater treatment, 3rd edn. CRC Press, Boca Raton
Hermanowicz SW, Ganczarczyk JJ (1983) Some fluidization characteristics of biological beds. Biotechnol Bioeng 25(5):1321–1330. https://doi.org/10.1002/bit.260250512
Koerich DM, Rosa LM (2017) Optimization of bioreactor operating conditions using computational fluid dynamics techniques. Can J Chem Eng 95:199–204. https://doi.org/10.1002/cjce.22635
Koerich DM, Lopes GC, Rosa LM (2018) Investigation of phases interactions and modification of drag models for liquid–solid fluidized bed tapered bioreactors. Powder Technol 339:90–101. https://doi.org/10.1016/j.powtec.2018.07.102
Kunii D, Levenspiel O (1991) Fluidization engineering, 2nd edn. Butterworth-Heinemann, Boston
Legendre D, Magnaudet J (1997) A note on the lift force on a bubble or a drop in a low-Reynolds-number shear flow. Phys Fluids 9(11):3572–3574. https://doi.org/10.1063/1.869466
Mulcahy LT, Shieh WK (1987) Fluidization and reactor biomass characteristics of the denitrification fluidized bed reactor. Water Res 21(4):451–458. https://doi.org/10.1016/0043-1354(87)90193-X
Murthy JSN, Reddy VS, Tasleem S, Kumar DV, Krishna CS, Sankarshana T (2009) Hydrodynamics of gas–solid fluidization in tapered beds. Can J Chem Eng 87:359–374. https://doi.org/10.1002/cjce.20180
Ngian K, Martin WRB (1980) Bed expansion characteristics of liquid fluidized bed particles with attached microbial growth. Biotechnol Bioeng 22:1843–1856. https://doi.org/10.1002/bit.260220906
Nicolella C, van Loosdrecht MCM, Di Felice R, Rovatti M (1999) Terminal settling velocity and bed-expansion characteristics of biofilm-coated particles. Biotechnol Bioeng 62(1):62–70. https://doi.org/10.1002/(SICI)1097-0290(19990105)62:1%3c62:AID-BIT8%3e3.0.CO;2-U
Nicolella C, van Loosdrecht MCM, Heijnen JJ (2000) Wastewater treatment with particulate biofilm reactors. J Biotechnol 90(1):1–33. https://doi.org/10.1016/S0168-1656(00)00229-7
Peng Y, Fan LT (1997) Hydrodynamic characteristics of fluidization in liquid–solid tapered beds. Chem Eng Sci 52(14):2277–2290. https://doi.org/10.1016/S0009-2509(97)00061-4
Ratkovich N, Majumder SK, Bentzen TR (2013) Empirical correlations and CFD simulations of vertical two-phase gas–liquid (Newtonian and non-Newtonian) slug flow compared against experimental data of void fraction. Chem Eng Res Des 91(6):988–998. https://doi.org/10.1016/j.cherd.2012.11.002
Ren TT, Mu Y, Liu L, Li XY, Yu HQ (2009) Quantification of the shear stresses in a microbial granular sludge reactor. Water Res 43(18):4643–4651. https://doi.org/10.1016/j.watres.2009.07.019
Richardson JF, Zaki WN (1954) Sedimentation and fluidization: part 1. Trans Inst Chem Eng 32:35–53
Roache PJ (1997) Quantification of uncertainty in computational fluid dynamics. Annu Rev Fluid Mech 29:123–160. https://doi.org/10.1146/annurev.fluid.29.1.123
Rosa LM, Koerich DM, Della Giustina SV (2017) The use of CFD in design and optimization of wastewater treatment units: a review. In: Collins M (ed) Organic waste: management strategies, environmental impact and emerging technologies. Nova Science Publishers, New York, pp 71–140
Saravanan V, Sreekrishnan TR (2005) Hydrodynamic study of biogranules obtained from an anaerobic hybrid reactor. Biotechnol Bioeng 91(6):715–721. https://doi.org/10.1002/bit.20567
Schaafsma SH, Marx T, Hoffmann AC (2006) Investigation of the particle flowpattern and segregation in tapered fluidized bed granulators. Chem Eng Sci 61:4467–4475. https://doi.org/10.1016/j.ces.2006.01.040
Scott CD, Hancher CW (1976) Use of a tapered fluidized bed as a continuous bioreactor. Biotechnol Bioeng 18:1393–1403. https://doi.org/10.1002/bit.260181006
Sindall R, Bridgeman J, Carliell-Marquet C (2013) Velocity gradient as a tool to characterise the link between mixing and biogas production in anaerobic waste digesters. Water Sci Technol 67(12):2800–2806. https://doi.org/10.2166/wst.2013.206
Tchobanoglous G, Burton FL, Stensel HD (2003) Metcalf & Eddy wastewater engineering: treatment and reuse, 4th edn. McGrawHill, New York
Wright MR, Bach C, Gernaey KV, Krühne U (2018) Investigation of the effect of uncertain growth kinetics on a CFD based model for the growth of S. cerevisiae in an industrial bioreactor. Chem Eng Res Des 140:12–22. https://doi.org/10.1016/j.cherd.2018.09.040
Wu CS, Huang JS, Reiko O (2009) Hydrodynamics of tapered anaerobic fluidized beds for metabolic gas production. Chem Eng J 148(15):279–289. https://doi.org/10.1016/j.cej.2008.08.030
Yang WC (2003) Handbook of fluidization and fluid-particle systems, 1st edn. Marcel-Dekker Inc., New York
Acknowledgements
This work was supported by the National Council for Scientific and Technological Development (CNPq), through Project Number 830795/1999-5. The authors also thank Dr. Tommaso Oggian for his insights reviewing this paper.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Koerich, D.M., Lopes, G.C. & Rosa, L.M. Numerical study on the hydrodynamics of a fluidized-bed of bioparticles in tapered bioreactors with square shape cross-section. Braz. J. Chem. Eng. 37, 101–115 (2020). https://doi.org/10.1007/s43153-020-00010-4
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s43153-020-00010-4