Abstract
Silicon crystal for solar cells are mainly produced by the Czochralski (CZ) method, in which the quality and production cost of silicon crystal are mainly affected by the thermal field of the crystal growth furnace. While the thermal field is significantly influenced by the heat shield material, in this study, the effect of thermal conductivity and emissivity of the heat shield material on the global thermal field was investigated by numerical simulation in Ansys Fluent software. The heat shield surface is divided into two parts, the high-temperature side part (close to the crucible and melt) and the low-temperature side part (close to the crystal), which are named as Hot-Side-Material and Cold-Side-Material, respectively. The results show that the same material can be chosen for both parts and the smaller the thermal conductivity and the emissivity of the material, the better the thermal field. As the thermal conductivity and emissivity of the heat shield surface material decrease, the melt-crystal (m-c) interface deflection decreases; the maximum thermal stress of the crystal and the required heater power are also reduced, while the crystal axial temperature gradient increases. Therefore, it is recommended to select material with low emissivity and low thermal conductivity as heat shield surface material.
Similar content being viewed by others
Data Availability
No datasets were generated or analysed during the current study.
References
Vegad M, Bhatt NM (2014) Review of some aspects of single crystal growth using Czochralski Crystal growth technique. Procedia Technol 14:438–446. https://doi.org/10.1016/j.protcy.2014.08.056
Bye G, Ceccaroli B (2014) Solar grade silicon: technology status and industrial trends. Sol Energ Mat Sol C 130:634–646. https://doi.org/10.1016/j.solmat.2014.06.019
Coletti G, Gordon I, Schubert MC et al (2014) Challenges for photovoltaic silicon materials. Sol Energ Mat Sol C 130:629–633. https://doi.org/10.1016/j.solmat.2014.07.045
Teng R, Zhou Q, Dai X et al (2012) Optimization of heat shield for single silicon crystal growth by using numerical simulation. Rare Met 31(5):489–493. https://doi.org/10.1007/s12598-012-0545-0
Cao J, Gao Y, Chen Y et al (2011) Simulation aided hot zone design for faster growth of CZ silicon mono crystals. Rare Met 30(2):155–159. https://doi.org/10.1007/s12598-011-0216-6
Nam W, Hahn Y, Baik S (2017) Local optimization of graphite heater to save a power consumption of Czochralski Si ingot grower for PV application. Energy Procedia 124:767–776. https://doi.org/10.1016/j.egypro.2017.09.083
Zhou B, Chen W, Li Z et al (2018) Reduction of oxygen concentration by heater design during Czochralski Si Growth. J Cryst Growth 483:164–168. https://doi.org/10.1016/j.jcrysgro.2017.11.008
Nguyen T-H-T, Chen J-C, Li C-H (2023) Controlling the heat, flow, and oxygen transport by double-partitions during continuous czochralski (CCz) silicon crystal growth. Mat Sci Semicon Proc 155:107235. https://doi.org/10.1016/j.mssp.2022.107235
Lin CH, Chen PW, Chen CY (2011) Simulations of Silicon Cz Growth in a cusp magnetic field. Magnetohydrodynamics 47(1):17–28. https://doi.org/10.22364/mhd.47.1.3
Jawaid M, Guan XJ, Zhang XY et al (2016) Simulation of V/G during Φ450 mm Czochralski grown silicon single crystal growth under the different crystal and crucible rotation rates. MATEC Web Conf 67:02002. https://doi.org/10.1051/matecconf/20166702002
Ding J, Liu L (2019) The influence mechanism of melt flow instability on the temperature fluctuation on the crystal/melt interface during Czochralski silicon crystal growth. Int J Heat Mass Transf 142:118463. https://doi.org/10.1016/j.ijheatmasstransfer.2019.118463
Ding J, Liu L (2018) Real-time prediction of crystal/melt interface shape during Czochralski crystal growth. CrystEngComm 20(43):6925–6931. https://doi.org/10.1039/c8ce01503a
Li J, Li Z, Liu L et al (2023) Effects of melt depth on oxygen transport in silicon crystal growth by continuous-feeding czochralski method. J Cryst Growth 610:127180. https://doi.org/10.1016/j.jcrysgro.2023.127180
Nguyen T-H-T, Chen J-C, Lo S-C (2022) Effects of different partition depths on heat and oxygen transport during continuous czochralski (CCz) silicon crystal growth. J Cryst Growth 583:126546. https://doi.org/10.1016/j.jcrysgro.2022.126546
Zhang J, Liu D, Zhao Y et al (2014) Impact of heat shield structure in the growth process of Czochralski silicon derived from numerical simulation. Chin J Mech Eng-En 27(3):504–510. https://doi.org/10.3901/cjme.2014.03.504
Hu R, Lv X, Li J et al (2023) The effect of physical property parameters of the insulation material inside the heat shield on the growth of Czochralski silicon crystal. Silicon. https://doi.org/10.1007/s12633-023-02778-9
Chen S, Liu W, Li M et al (2022) Melt convection and temperature distribution in 300 mm czochralski crystal growth with transverse magnetic field. J CRYST GROWTH 591:126722. https://doi.org/10.1016/j.jcrysgro.2022.126722
Shati A, Blakey S, Beck S (2011) The effect of surface roughness and emissivity on radiator output. Energy Build 43(2–3):400–406. https://doi.org/10.1016/j.enbuild.2010.10.002
Qi X, Ma W, Dang Y et al (2020) Optimization of the melt/crystal interface shape and oxygen concentration during the Czochralski silicon crystal growth process using an artificial neural network and a genetic algorithm. J Cryst Growth 548:125828. https://doi.org/10.1016/j.jcrysgro.2020.125828
Kirpo M (2013) Global simulation of the Czochralski silicon crystal growth in ANSYS FLUENT. J Cryst Growth 371:60–6960. https://doi.org/10.1016/j.jcrysgro.2013.02.005
Jelle BP, Kalnæs SE, Gao T (2015) Low-emissivity materials for building applications: a state-of-the-art review and future research perspectives. Energy Build 96:329–356. https://doi.org/10.1016/j.enbuild.2015.03.024
Fioretti R, Principi P (2014) Thermal performance of hollow clay brick with low emissivity treatment in surface enclosures. Coatings 4(4):715–731. https://doi.org/10.3390/coatings4040715
Sim B-C, Jung Y-H, Lee H-W (2009) Effect of the ingot cooling on the grown-in defects in silicon Czochralski growth. Jpn J Appl Phys 48(10R):105503. https://doi.org/10.1143/JJAP.48.105503
Liu M, Xu H, Nan Peng (2022) A simulation study of enhanced radiation cooling on a radiator with high emissivity coating. Int Cryog Eng Conf Int Cryog Mater Conf 2022:551–558. https://doi.org/10.1007/978-981-99-6128-3_71
Funding
The authors are grateful for financial support from the Natural Science Foundation of Gansu Province (Grant No. 20JR5RA240) and Lanzhou University Supercomputing Center.
Author information
Authors and Affiliations
Contributions
Xuekang Lv: Conceptualization, Formal analysis, Methodology, Software, Visualization, Writing-original draft. Rongrong Hu: Data Curation, Formal analysis, Methodology, Visualization, Writing - Review & Editing. Jiacheng Li: Investigation, Data curation. Salamat Ali: Data curation, Writing – review & editing. Geng** Li: Investigation. **g Qi: Supervision, Writing - Review & Editing.
Corresponding author
Ethics declarations
Consent for Publication
All authors have checked the manuscript and have agreed to the submission.
Ethics Approval
The authors declare that the manuscript is not currently being considered for publication in another journal.
Consent to Participate
The consent was obtained from individual or guardian participants.
Competing Interests
The authors declare no competing interests.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Lv, X., Hu, R., Li, J. et al. Influence of Thermal Conductivity and Emissivity of Heat Shield Surface Material on the Thermal Field of Czochralski Silicon Crystal Growth. Silicon (2024). https://doi.org/10.1007/s12633-024-03044-2
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s12633-024-03044-2