Abstract
Oil-paper insulation in transformers plays an important role in the operation of power grid. At present, the aging (life assessment) of transformers are mainly conducted based upon the degree of polymerization, concentration of furfural, and the gas analysis of CO and CO2 in the transformer oil. However, these techniques lack sensitive response, especially in the early aging of oil-paper insulation. Methanol as a new indicator to evaluate the aging of insulating paper, is getting more and more attention. An evaluation method based on the measurement of methanol concentration using ultraviolet–visible spectrometer was proposed in this work. After the extraction from transformer oils, the methanol was oxidized using potassium permanganate. Then, chromotropic acid was used to react with the oxidation products (formaldehyde) to form a mauve clathrate, finally, the methanol content was measured using the spectroscopy. Different from traditional spectroscopy which calculate only by absorbance at the characteristic wavelength, this paper use the partial least squares method, obtain the relationship between the absorbance at selected regions and the concentration of methanol. The minimum detection limit for the proposed method was 10 ppb, whereas the correlation coefficient for the relationship between the absorbance and the concentration of methanol was as high as 0.99.
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig1_HTML.png)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig2_HTML.png)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig3_HTML.png)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig4_HTML.png)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig5_HTML.png)
![](http://media.springernature.com/m312/springer-static/image/art%3A10.1007%2Fs42835-019-00097-x/MediaObjects/42835_2019_97_Fig6_HTML.png)
Similar content being viewed by others
References
Li J, Wang Y, Bao L (2014) Space charge behavior of oil-impregnated paper insulation aging at AC–DC combined voltages. J Electr Eng Technol 9(2):635–642
Qian Y, **ao H, Nie M et al (2018) Lifetime prediction and aging behaviors of nitrile butadiene rubber under operating environment of transformer. J Electr Eng Technol 13(2):918–927
Liao R, Yang L, Xu Z (2015) The investigation on thermal aging characteristics of oil-paper insulation in bushing. J Electr Eng Technol 10(3):1114–1123
Zhou YX, Huang M, Chen WJ et al (2015) Space charge behavior of oil-paper insulation thermally aged under different temperatures and moistures. J Electr Eng Technol 10(3):1124–1130
Kim J, Kim W, Park HS et al (2017) Lifetime assessment for oil-paper insulation using thermal and electrical multiple degradation. J Electr Eng Technol 12(2):840–845
Rodriguez-Celis EM, Duchesne S, Jalbert J et al (2015) Understanding ethanol versus methanol formation from insulating paper in power transformers. Cellulose 22(5):3225–3236
Setnescu R, Badicu LV, Dumitran LM et al (2014) Thermal lifetime of cellulose insulation material evaluated by an activation energy based method. Cellulose 21(1):823–833
Norazhar AB, Abu-Siada A, Islam S (2014) A review on chemical diagnosis techniques for transformer paper insulation degradation. In: Power engineering conference. IEEE, pp 1–6
Laurichesse D, Bertrand Y, Tran-Duy C et al (2013) Ageing diagnosis of MV/LV distribution transformers via chemical indicators in oil. In: Electrical insulation conference. IEEE
Kes M, Christensen BE (2013) Degradation of cellulosic insulation in power transformers: a SEC–MALLS study of artificially aged transformer papers. Cellulose 20(4):2003–2011
Jalbert J, Duchesne S, Rodriguez-Celis E et al (2012) Robust and sensitive analysis of methanol and ethanol from cellulose degradation in mineral oils. J Chromatogr A 1256(18):240
Tang S, Peng G, Zhong Z (2016) Quantitative spectral analysis of dissolved gas in transformer oil based on the method of optimal directions. In: Control conference. IEEE, pp 4425–4429
Jalbert J, Gilbert R, Denos Y et al (2012) Methanol: a novel approach to power transformer asset management. IEEE Trans Power Deliv 27(2):514–520
Pahlavanpour B, Duffy G (1993) Development of a rapid spectrophotometry method for analysis of furfuraldehyde in transformer oil as an indication of paper ageing. In: Conference on electrical insulation and dielectric phenomena, 1993 report. IEEE, pp 493–498
Kóréh O, Torkos K, Mahara MB et al (1998) Extraction and quantitation of furanic compounds dissolved in oils. J Radioanal Nucl Chem 228(1–2):47–52
ASTM D5837-2005 (2005) Standard test method for furanic compounds in electrical insulating liquids by high-performance liquid chromatography (HPLC)
Okabe S, Kaneko S, Kohtoh M et al (2010) Analysis results for insulating oil components in field transformers. IEEE Trans Dielectr Electr Insul 17(1):302–311
Arroyo OH, Fofana I, Jalbert J et al (2016) Relationships between methanol marker and mechanical performance of electrical insulation papers for power transformers under accelerated thermal ageing. IEEE Trans Dielectr Electr Insul 22(6):3625–3632
Schaut A, Autru S, Eeckhoudt S (2011) Applicability of methanol as new marker for paper degradation in power transformers. IEEE Trans Dielectr Electr Insul 18(2):533–540
Gilbert R, Jalbert J, Tétreault P et al (2009) Kinetics of the production of chain-end groups and methanol from the depolymerization of cellulose during the ageing of paper/oil systems. Part 1: standard wood kraft insulation. Cellulose 16(2):327–338
Gilbert R, Jalbert J, Duchesne S et al (2010) Kinetics of the production of chain-end groups and methanol from the depolymerization of cellulose during the ageing of paper/oil systems. Part 2: thermally-upgraded insulating papers. Cellulose 17(2):253–269
Matharage SY, Liu Q, Wang ZD et al (2018) Aging assessment of synthetic ester impregnated thermally non-upgraded kraft paper through chemical markers in oil. IEEE Trans Dielectr Electr Insul 25(2):507–515
Bruzzoniti MC, Maina R, Carlo RMD et al (2014) GC methods for the determination of methanol and ethanol in insulating mineral oils as markers of cellulose degradation in power transformers. Chromatographia 77(15–16):1081–1089
Matharage SY, Liu Q, Wang ZD (2016) Ageing assessment of kraft paper insulation through methanol in oil measurement. IEEE Trans Dielectr Electr Insul 23(3):1589–1596
Molavi H, Yousefpour A, Mirmostafa A et al (2017) Static headspace GC/MS method for determination of methanol and ethanol contents, as the degradation markers of solid insulation systems of power transformers. Chromatographia 80(7):1129–1135
Matharage SY, Liu Q, Davenport E et al (2014) Methanol detection in transformer oils using gas chromatography and ion trap mass spectrometer. In: IEEE, international conference on dielectric liquids. IEEE, pp 1–4
Chen S, Ma Y, Qu CT et al (2011) Improvement of chromotropic acid spectrophotometry for determining methanol content in gas production wastewater. J **’an Shiyou Univ 26:70–74
Guo Q, Small GW (2013) Quantitative determination of methanol and ethanol with synthetic calibration spectra in passive Fourier transform infrared remote sensing measurements. Appl Spectrosc 67(8):913–923
Acknowledgements
The work was supported financially by the China Southern Power Grind (Grant No. GDKJQQ20152046) and National Natural Science Foundation of China (51507129).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Fu, Q., Peng, L., Li, L. et al. Detection of Methanol in Power Transformer Oil Using Spectroscopy. J. Electr. Eng. Technol. 14, 861–867 (2019). https://doi.org/10.1007/s42835-019-00097-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s42835-019-00097-x